Manual Transmission Symptoms (760) 741-7861

Transmission Repair

Transmission
Symptoms


The Symptoms listed below are typical problems and are indicators only and are not intended to be a diagnoses. If you suspect you have a problem with your trsnsmission have it inspected by a professional.

Review the symptoms listed below and if any of them are present
Call Escondido Transmission (760) 741-7861
today and schedule a free external transmission diagnostic.

Pops Out Of Gear Noise In All Gears
Noise In Any One Gear Noise In Neutral W-Engine On
Noise In Reverse Only Excessive Backlash
Oil Leakage Clutch Fails To Release
Clutch Slips Hard Going Into Gear
Clutch Chatters Sqeals When Clutch Is Engaged
Clutch Doesn’T Return

Manual Transmission & Transaxle Trouble Symptoms


POPS OUT OF GEAR

  • Transmission is loose on bell housing.
  • Shift linkage interference or binding.
  • Worn or loose pilot bearing
  • Bearing retainer broken or loose.
  • Misaligned or debris between the bell housing & engine
  • Worn bearings & synchronizers.

If any of these symptoms are present call Escondido Transmission today and schedule a free external transmission diagnostic. Remember most transmission and clutch repairs are minor when serviced immediately

NOISE IN ALL GEARS

  • Low or no lubrication
  • Worn or damaged gears.
  • Worn or damaged bearings
  • Worn or damaged anti-lash plate

Call Escondido Transmission today and schedule a free external transmission diagnostic. Remember most transmission and clutch repairs are minor when serviced immediately

NOISE IN ANY ONE GEAR

  • Worn or damaged bearings
  • Worn or damaged synchronizers
  • Worn or damaged gear

If any of these symptoms are present call Escondido transmission today and schedule a free external transmission diagnostic. Remember most transmission and clutch repairs are minor when serviced immediately

NOISE IN NEUTRAL W-ENGINE ON

  • Worn or damaged input shaft bearing
  • Worn or damaged pilot bearing
  • Worn or damaged anti-lash plate.
  • Worn or damaged bearings or shims

If any of these symptoms are present call Escondido Transmission today and schedule a free external transmission diagnostic. Remember most transmission and clutch repairs are minor when serviced immediately

NOISE IN REVERSE ONLY

  • Worn or damaged reverse idler gear.
  • Worn or damaged reverse idler bushings.
  • Worn or damaged reverse counter gear

If any of these symptoms are present call Escondido Transmission today and schedule a free external transmission diagnostic. Remember most transmission and clutch repairs are minor when serviced immediately

EXCESSIVE BACKLASH

  • Worn or damaged bearings
  • Excessive end play in counter shaft

If any of these symptoms are present call Escondido Transmission today and schedule a free external transmission diagnostic. Remember most transmission and clutch repairs are minor when serviced immediately

Oil LEAKAGE

  • Transmission maybe over full.
  • Loose bearing retainer.
  • Damaged bearing retainer seal.
  • Old shift rail plugs
  • Loose covers and seals.
  • Damaged output shaft seal.
  • Damaged lever seals.
  • Case halves seals

If any of these symptoms are present call Escondido Transmission today and schedule a free external transmission diagnostic. Remember most transmission and clutch repairs are minor when serviced immediately

CLUTCH FAILS TO RELEASE

  • Master or slave cylinder leakage
  • Clutch disk warped or damaged

If any of these symptoms are present call Escondido Transmission today and schedule a free external transmission diagnostic. Remember most transmission and clutch repairs are minor when serviced immediately

CLUTCH SLIPS

  • Clutch disk oil soaked
  • Clutch disk worn thin
  • Clutch disk not seated
  • Pressure plate worn.

If any of these symptoms are present call Escondido Transmission today and schedule a free external transmission diagnostic. Remember most transmission and clutch repairs are minor when serviced immediately

HARD GOING INTO GEAR

  • Pressure plate is not releasing disk completely
  • Linkage damaged or out of adjustment.
  • Hydraulic system malfunction

If any of these symptoms are present call Escondido Transmission today and schedule a free external transmission diagnostic. Remember most transmission and clutch repairs are minor when serviced immediately

CLUTCH CHATTERS

  • Oil on clutch disk.
  • Broken or loose mounts.
  • Spline on clutch hub stripping.
  • Warped pressure plate or flywheel.

If any of these symptoms are present call Escondido Transmission today and schedule a free external transmission diagnostic. Remember most transmission and clutch repairs are minor when serviced immediately

SQUEALS WHEN CLUTCH IS ENGAGED

  • Worn release bearing
  • Release bearing is binding on support

If any of these symptoms are present call Escondido Transmission today and schedule a free external transmission diagnostic. Remember most transmission and clutch repairs are minor when serviced immediately

CLUTCH DOESN’T RETURN

  • Linkage or release bearing binding

If any of these symptoms are present call Escondido Transmission today and schedule a free external transmission diagnostic. Remember most transmission and clutch repairs are minor when serviced immediately